Call us +(86)18678002095 |
MON-FRI. 9:00 - 19:00 +8GTM
Associated petroleum gas »
Generator Set
for sale
153
42 variants for sale
Associated petroleum gas is a type of natural gaseous hydrocarbon produced during oil production.
The composition of Associated petroleum gas is heterogeneous and may vary depending on the field and production characteristics. And the percentage composition of the elements below also varies.
CH4 - Methane,
C2H6 - Ethane,
C5H12 - Pentane and heavy hydrocarbons,
C7H8 Toluene - phenylmethane, methylbenzene,
C6H6, PhH - Benzene,
C3H8 - Propane,
C4H10 - Bhutan,
C6H14 - Hexane,
H2S - Hydrogen Sulfide,
N2 - Nitrogen,
O2 - Oxygen,
CO2 Carbon Dioxide (carbon dioxide),
He is Helium
as well as Water and Sulfur
Any natural gas-fuelled piston generator can be used to run on associated gas.
However, direct use of associated petroleum gas in power plant operation is impossible due to its heterogeneous composition, which consists of various impurities mentioned above.
For this purpose, a separation method is used.
Our associated gas pre-treatment and treatment system is designed to purify the gas by removing sulphur, hydrogen sulphide, water and a mixture of gases that do not meet the standards of natural gas used in gas piston engines. It also stabilises the gas pressure at the outlet.
H2S scrubber tower -1 pc
Iron oxide desulphuriser - 18 pc
High pressure water separator -1 pc
Gas separator -1 pc
Mass filter -1 pc
Fine filter -2 pcs
Pressure decompression station -1 pc
Note: The working pressure of the desulphurisation tower is 50 KP.
The working pressure of the low-pressure water separator is 50 Kpa.
Working pressure of high pressure gas and water separator, coarse filter and fine filter is 6.3 MPa. =
BENEFITS:
Associated petroleum gas power plants turn the oil waste from extraction into your substantial income.
The cost of light produced is two or more times lower than that supplied from the central grid.
You get a short payback period, since the efficiency of power plants using
Associated petroleum gas as fuel is 80 per cent or higher, their payback period is about two to three years.
If you use a plant for heating water heated by burning gas fuel, this period is shortened.
There is also Improvement of the environmental situation in the area of oil production.
No need to run electric lines to the oil fields.
Oil, as a rule, is extracted in remote areas where it is difficult to deliver electricity.
Installation of an APG-fuelled station allows to supply electricity not only to the field itself,
but also to the infrastructure located nearby.
Gas-piston power plants are unpretentious, not afraid of temperature fluctuations and dust,
so they can be installed outdoors.
They work perfectly in harsh climatic conditions of hot deserts and the Far North.
The composition of Associated petroleum gas is heterogeneous and may vary depending on the field and production characteristics. And the percentage composition of the elements below also varies.
CH4 - Methane, C2H6 - Ethane, C5H12 - Pentane and heavy hydrocarbons, C7H8 Toluene - phenylmethane, methylbenzene, C6H6, PhH - Benzene, C3H8 - Propane, C4H10 - Bhutan, C6H14 - Hexane, H2S - Hydrogen Sulfide, N2 - Nitrogen, O2 - Oxygen, CO2 Carbon Dioxide (carbon dioxide), He is Helium
as well as Water and Sulfur
Any natural gas-fuelled piston generator can be used to run on associated gas.
However, direct use of associated petroleum gas in power plant operation is impossible due to its heterogeneous composition, which consists of various impurities mentioned above.
For this purpose, a separation method is used.
Our associated gas pre-treatment and treatment system is designed to purify the gas by removing sulphur, hydrogen sulphide, water and a mixture of gases that do not meet the standards of natural gas used in gas piston engines. It also stabilises the gas pressure at the outlet.
Our Haitai Power company© has developed a unique automatic filtration system based on the principle of gravity method,
which distributes the gas and liquid phases, thereby removing free water in the oil associated gas.
As well as a dry desulphurisation system, a sulphur removal system and filtration of gases and other impurities.
These separators are supplied with the purchased gas generator. They are designed for a minimum capacity of 400m3/hour to 2000m3/hour
Standard composition of the separation stationThese separators are supplied with the purchased gas generator. They are designed for a minimum capacity of 400m3/hour to 2000m3/hour
H2S scrubber tower -1 pc
Iron oxide desulphuriser - 18 pc
High pressure water separator -1 pc
Gas separator -1 pc
Mass filter -1 pc
Fine filter -2 pcs
Pressure decompression station -1 pc
Note: The working pressure of the desulphurisation tower is 50 KP.
The working pressure of the low-pressure water separator is 50 Kpa.
Working pressure of high pressure gas and water separator, coarse filter and fine filter is 6.3 MPa. =
BENEFITS:
Associated petroleum gas power plants turn the oil waste from extraction into your substantial income. The cost of light produced is two or more times lower than that supplied from the central grid. You get a short payback period, since the efficiency of power plants using
Associated petroleum gas as fuel is 80 per cent or higher, their payback period is about two to three years. If you use a plant for heating water heated by burning gas fuel, this period is shortened. There is also Improvement of the environmental situation in the area of oil production. No need to run electric lines to the oil fields. Oil, as a rule, is extracted in remote areas where it is difficult to deliver electricity. Installation of an APG-fuelled station allows to supply electricity not only to the field itself,
but also to the infrastructure located nearby. Gas-piston power plants are unpretentious, not afraid of temperature fluctuations and dust,
so they can be installed outdoors. They work perfectly in harsh climatic conditions of hot deserts and the Far North.
THE ADVANTAGES OF GAS PISTON POWER PLANTS USING ASSOCIATED PETROLEUM GAS ALSO INCLUDE:
Lower emissions and reduced environmental impact.
Reduced dependence on imported fuels and increased energy security.
Reduction of greenhouse gas emissions through rational utilisation of associated gas.
Creation of jobs and development of engineering and technical specialities.
Possibility to use hot water vapour and heat in additional technical processes.
Associated gas, unlike natural gas, is subject to a zero tax rate of mineral extraction tax.
Lower emissions and reduced environmental impact. Reduced dependence on imported fuels and increased energy security. Reduction of greenhouse gas emissions through rational utilisation of associated gas. Creation of jobs and development of engineering and technical specialities. Possibility to use hot water vapour and heat in additional technical processes. Associated gas, unlike natural gas, is subject to a zero tax rate of mineral extraction tax.
WE OFFER FOR YOU Consultation on the choice of equipment The possibility of OEM production according to your order Direct sale from our factory in China Targeted Delivery Commissioning works Staff training Warranty and spare parts Lifetime service
1100kw Baudouin Natural Gas HTG-1100GF GenSet
1400kw Baudouin Natural Gas HTG-1400GF GenSet
Jichai 3600GF10-T LNG CNG Natural Gas Generator Set
Jichai 1200GF-T LNG CNG Natural Gas Generator Set
Jichai 2000GF10-T LNG CNG Natural Gas Generator Set
Jichai 1100GF9-T2 LNG CNG Natural Gas Generator Set
3200kw Jichai 3200GF LNG CNG Natural Gas Generator Set
500kW Baudouin Natural Gas GenSet
230kW Baudouin Natural Gas HTG-230GF GenSet
250kW Baudouin Natural Gas HTG-250GF GenSet
400kW Baudouin Natural Gas HTG-400GF GenSet
720kW Baudouin Natural Gas HTG-720GF GenSet
250kW MAN Natural Gas Gensets CHPs HTG-250GF
250kW Cummins LNG CNG Gas Genset HTG-250GF
300kW Haitai-Sinotruk Natural Gas GenSet HTG-300GF
280kW Sinotruk Natural Gas GenSet HTG-280GF
250kW Haitai-Sinotruk Natural Gas GenSet HTG-250GF
520kW Man industrial biogas GenSet HTG-520GF
1MW Baudouin Natural Gas HTG-1000GF GenSet
800kW Baudouin Natural Gas HTG-800GF GenSet
301kW Doosan LNG CNG Methane Gas Genset HTG-301GF
230kW Weichai LNG CNG Methane Gas Genset HTG-230GF
800kW Weichai BioGas Genset HTG-800GF
Haven't found what you want?
If you can't find what you are looking for,
simply contact us either by using the form below.
We will provide you what you need
in the shortest possible time and at the lowest price. Since this website does not present our entire assortment.
My Cart